Product ID:SATIN PLASTI-THANE CLEAR, 35-182
MSDS Date:09/24/1987
FSC:8010
NIIN:00N049632
MSDS Number: BTZHV

PRESERVATIVE PAINT CO

5400-5410 AIRPORT WAY SOUTH
SEATTLE, WA 98108
US

Emergency Phone: 206-526-2121

Info Phone: 206-526-2121

Cage: 86589

PRESERVATIVE PAINT CO

80387 SEATTLE, WA 98108-1726 US

Cage: 86589

MINERAL SPIRITS

CAS: 64742-88-7

OSHA PEL N/K

ACGIH TLV: 500 PPM (MFR)

CRYSTALLINE SILICA; (SILICA)

CAS: 7631-86-9

OSHA PEL N/K

ACGIH TLV: 6 MG/M3 (MFR)

MINERAL SPIRITS

CAS: 64742-88-7

OSHA PEL N/K

ACGIH TLV: 100 PPM (MFR)

LIGROINE; (ODORLESS MINERAL SPIRITS)

CAS: 8032-32-4

RTECS: OI6180000

OSHA PEL 300 PPM; 400 STEL

ACGIH TLV: 300 PPM

MANGANESE ALKANOATE

OSHA PEL N/K

ACGIH TLV: 5 MG/M3 (MFR)

2-BUTANONE, OXIME; (METHYL ETHYL KETOXIME)

CAS: 96-29-7

RTECS: EL9275000

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE NOSE & THROAT
IRRITATION. MAY CAUSE NERVOUS SYSTEM DEPRESSION CHARACTERIZED BY
FOLLOWING STEPS: HEADACHE, DIZZINESS, NAUSEA, STAGGERING GAIT,
CONFUSION & UNCONSCIOUSNESS. MAY CAUSE IR RITATION OR BURNING OF
EYES. REPEATED OR PROLONGED LIQUID CONTACT MAY CAUSE SKIN
IRRITATION WITH (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: DISCOMFORT & DERMATITIS. CHRONIC:
REPORTS HAVE ASSOCIATED REPEATED & PROLONGED OVEREXPOSURE TO
SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. OVERSPRAY &
MISTS ARE PRIMARILY CONSIDER ED A NUISANCE DUST. PIGMENTS ARE NOT
NORMALLY CONSIDERED HAZARDOUS WHEN PRESENT IN A PRODUCT MIXTURE.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS INVOLVING
SKIN, LIVER, KIDNEY AND PULMONARY DISORDERS.

First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION, PREFERABLY MOUTH-TO-MOUTH. IF BREATHING DIFFICULTY
PERSISTS/OCCURS LATER, CONSULT MD. EYES: IMMEDIATELY FLUSH WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL MD.SKIN: WASH WITH
SOAP & WATER. IF IRRITATION OCCURS, CONTACT MD. INGEST: IN UNLIKELY
EVENT OF INGESTION, CALL MD IMMEDIATELY. DO NOT INDUCE VOMITING.

Flash Point Method:TCC
Flash Point:105F,41C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL CLOSED CONTAINERS WITH WATER FOG TO
PREVENT PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. VAP IS DENSER
THAN AIR & CAN TRAVEL & COLLECT IN LOW SPOTS. ISOLATE FROM HEAT,
ELEC EQUIP SPKS & OPEN FLAME. CLSD CNTNRS MAY (SUPDAT)

Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. PREVENT SKIN CONTACT & BREATHING OF VAPORS. CONFINE AND
REMOVE WITH INERT ABSORBENT MATERIAL. USE SPARK PROOF TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PREC. KEEP AWAY FROM
EXCESS HEAT, SPKS & OPEN FLAME. KEEP CLOSURE TIGHT WHEN NOT IN USE.
STORE IN UPRIGHT POSITION TO PVNT (SUPDAT)
Other Precautions:CNTNRS MAY BE HAZ WHEN EMPTIED. SINCE EMPTY CNTNRS
RETAIN RESIDUES, ALL HAZ PREC MUST BE OBSERVED. WHEN SPRAYING KEEP
SPRAY BOOTH CLEAN. AVOID BUILDUP OF SPRAY DUST/OVERSPRAY IN
BOOTH/DUCTS. DO NOT SA ND, FLAME CUT, BRAZE/WELD DRY (SUPDAT)

Respiratory Protection:PROPERLY FITTED VAPOR/PARTICULATE RESPIRATOR
APPROVED BY NIOSH/MSHA.
Ventilation:VENTILATION SUFFICIENT IN PATTERN & VOL TO KEEP VAP BELOW
APPLIC OSHA REQS. USE EXPLO-PROOF MECH DEVICE IF REQD.
Protective Gloves:SOLVENT IMPERVIOUS GLOVES.
Eye Protection:GOGGLES OR SFTY GLASSES W/SIDE SHIELD.
Other Protective Equipment:COVERALLS ARE RECOMMENDED. SOLVENT
IMPERVIOUS APRON RECOMMENDED IF BODY CONTACT MAY OCCUR. SAFETY
SHOWER & EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING
OR SMOKING. WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ: EXPLODE WHEN EXPOS TO EXTREME HEAT. DO NOT APPLY TO HOT
SURF. CAN CAUSE SPONT COMBUST (RAGS, ETC.). HNDLG/STOR PREC:
LEAKAGE. GROUND CNTNRS WHEN POURING. DO NOT STORE > 120F. KEEP &
STORE O UT OF REACH OF CHILDREN. OTHER PREC: COATING W/OUT
NIOSH/MSHA APPRVD RESP OR APPROP VENT.

Boiling Pt:B.P. Text:>313F,>156C
Vapor Pres:7
Vapor Density:4.8
Spec Gravity:0.9
Evaporation Rate & Reference:0.13 (BUAC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR & PIGMENTED COATINGS WITH CHARACTERISTIC
SOLVENT ODOR.
Percent Volatiles by Volume:60

Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SMOKE.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. ABSORB LARGE SPILLS WITH INERT MATERIAL. INCINERATE
OR DISPOSE ABSORBED MATERIAL IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL REQUIREMENTS. DO N OT INCINERATE IN CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.